20 mm Flak 38

German light anti-aircraft guns 20 mm one barrel and Flakvierling.
History, development, service, specifications, statistics, pictures and 3D model.

20mm Flak and its crew
A 20mm Flak and its crew, in a typical emplacement.

20 mm Flak 38, Flakvierling
Type:
light anti-aircraft gun

History:

By 1940 it was already appreciated that the low rate of fire of the 20 mm (0.787-in) Flak 30 was too low for future target speeds, so it was decided to increase the rate of fire in order to increase the possible numbers of projectiles hitting the target.
It was also decided to redesign the gun to get rid of the inherent jamming problem. Rheinmetall-Borsig was not given the contract for this project. It went instead to Mauser, who came up with a new gun that was outwardly similar to the Flak 30 but internally much was changed to provide a cyclic rate of fire of 420 to 480 rounds per minute. The ammunition, feed system and most of the carriage remained much the same as before. So did the complicated sights which were later simplified, as on the Flak 30.

The 20 mm Flak 38, as the Mauser, design was known, entered service in late 1940 and eventually replaced the Flak 30 on the production lines. It served alongside the Flak 30 and was also used by the Luftwaffe and the German navy. There was even a special version for use by the German army’s mountain units that could be broken down into pack loads. This used the same gun as the Flak 38, but the carriage was much smaller and lighter: it was known as the 2-cm Gebirgs-Flak 38 and was intended to be a dual-purpose weapon for use against ground targets as well as against aircraft.

By 1940 it was appreciated that aircraft targets were not only getting faster but also heavier and better protected against ground and air fire. Undertaken with typical German thoroughness, operational analysis revealed that although the high rate of fire of the Flak 38 was more likely to ensure a target hit, the low explosive payload of the projectile was unlikely to inflict enough damage to ensure a ‘kill’.

The only easy and immediate way to remedy this was to increase the number of barrels firing from one mounting, and thus the 20 mm Flakvierling 38 was developed. This was simply a single Flak 38 carriage modified to accommodate four barrels capable of firing at once. This combination became a dreaded aircraft-killer that constantly drew a toll of low-flying Allied aircraft right until the end of the war.

The first Flakvierling entered service in late 1940 and there were never enough of them. They were used by the German army, the Luftwaffe and the navy, and many self-propelled mountings, like the SdKfz 7-1 , were improvised or produced to make them more mobile.
There was a special version for use on armored trains and at one point there was even a radar-controlled version under development. The Flakvierling required a greater number of men to serve it in action (usually six or seven).

For the Germans there were never enough of them and throughout the Reich many production facilities were devoted to manufacture of the guns, their carriages and ammunition. This last was produced in several forms including high explosive (HE), high explosive with tracer and various forms of armor-piercing.


Pictures 20 mm Flak 38


Specifications for 20 mm Flakvierling 38

Specification:

20 mm Flakvierling 38Specification
Typelight anti-aircraft gun
Crew6-7
Length88.7 in
Weight 3,338 lb
Calibre20 mm (0.79in)
Elevation-10° to +100°
Muzzle velocity anti-aircraft shell: 2,953 ft / sec; anti-tank shell: 2,572 ft / sec; PzGr40 anti-tank shell: 3,402 ft / sec
Fire range 7,218 ft
Shell weight anti-aircraft shell: 0.262 lb ; anti-tank shell: 0.326 lb , PrGr40 anti-tank shell: 0.204 lb
Cyclic rate of fire 1800 rounds / min.

Penetration mm at 30° armor plates:

RangePzgrPzgr40 (just limited numbers)
Penetration 100 meters20 mm49 mm
Penetration 500 meters14 mm20 mm
Penetration 1,000 meters9 mm-


Production:

all versions 20 mm Flak 38figures
Production (Flakvierling)from late 1940 until May 1945
Price per unit (Flak 38 with one barrel) c. RM 4,000 = $ 1,800 $ = £ 380
Total production figure (all) c. 40,000 only from January 1942 to February 1945
Production 1942 c. 11,600
Production 1943 c. 14,700
Production 1944 c. 12,600
Production 1945 c. 1,300

Animated 3D model of 20 mm Flakvierling 38


References and literature

Luftwaffe Handbook (Dr Alfred Price)
Luftkrieg (Piekalkiewicz)
The Encyclopedia of Weapons of World War II (Chris Bishop)
Die Geschichte der Artillerie (John Batchelor, Ian Hogg)
Artillery in Colour 1920-1963 (Ian Hogg)


Oval@3x 2

Don’t miss the newest posts on Sunday!

We don’t spam! Read our privacy policy for more info.

for sharing:

2 thoughts on “20 mm Flak 38”

  1. “This was simply a single Flak 38 carriage modified to accommodate four barrels capable of firing at once”
    Wildly inaccurate.
    Other than the same actual 20mm gun and the Flakvisier 38/40 sight mounting to it, the Flakvierling 38 and the Sd.Ah.52 trailer are completely different in every respect from the single gun mount Flak 38.
    Simply put, The Sd.Ah.52 trailer for the quad mount weighs more than the entire single gun mount and trailer together.

    1. Stephen Etheridge

      U505 Submarine in the Museum of Science and Industry, in Chicago, has two Flakzwilling gun mounts installed on it’s Conning Tower.

Leave a Comment

Your email address will not be published. Required fields are marked *

This site uses Akismet to reduce spam. Learn how your comment data is processed.

Scroll to Top